Solve this!

  #1  
Old 02-22-2014, 09:50 PM
Junior Member
Thread Starter
Join Date: Feb 2014
Posts: 1
Angry Solve this!

I'm working on a 2001 VW passage front wheel drive V6 30V. Reason why it came to me it had an ABS problem brake light and it beeped three times. Got another ABS. Then got scanner and got P102 and that means MAF or VAF a CKT Intermittent. I did disconnect it when I started and took out filter and box then replace. So I had to replace passenger side c. V. Shaft and put it back together no it says p0102 or will switch to ABS brake???? I notices on MAF there is an cut black wire and all the others are right????? Please help and when I drive it jolts really hard once and again...
 
  #2  
Old 02-23-2014, 07:53 AM
Keithuk's Avatar
Super Moderator
Join Date: Sep 2009
Location: Stoke on Trent, England
Posts: 2,216
Default

Welcome to the forum. Name:  VWwelcome.gif
Views: 107
Size:  951 Bytes

Error codes are 4 characters or more so P102 isn't really valid as it could be:

P1020 Fuel Pressure Regulation - Control Range Exceeded
P1021 Camshaft Position (CMP) Sensor 'A', Bank 1 - Timing Over Advance or System Performance
P1022 Camshaft Position (CMP) Sensor 'A', Bank 1 - Timing Over Retarded
P1023 Fuel Pressure Regulation Valve (N276) - Short Circuit to Earth
P1024 Fuel Pressure Regulation Valve (N276) - Open Circuit
P1025 Fuel Pressure Regulation Valve (N276) - Mechanical Failure
P1026 Intake Manifold Air Control Solenoid - Short Circuit to Positive
P1027 Intake Manifold Air Control Solenoid - Short Circuit to Earth
P1028 Intake Manifold Air Control Solenoid - Open Circuit
P1029 Intake Manifold Runner Control (IMRC) Valve (N316) - Upper Limit not Reached


VAG Error Code: 16486
EOBD II Error Code: P0102

Fault Location:
Mass Air Flow (MAF) Sensor (G70), Bank 1 - Signal too Low/Short Circuit to Earth

Possible Cause:
Malfunction Indicator Lamp (MIL)(K83) active.
Engine stall.
Engine running rough.
Excessive fuel consumption.
Excessive smoke.
Loss or Power.

Intake leak.
Air filter blocked.
Wiring/Connector(s) short to earth.
Fuse(s).
Mass Air Flow (MAF) Sensor (G70) defective.
Dirty Mass Air Flow (MAF) Sensor (G70) air filter.

Possible Solutions:
Check/Replace all faulty Wiring/Connector(s).
Read Measuring Value Blocks (MVB).
Check/Replace Mass Air Flow (MAF) (G70).
Mass Air Flow (MAF) Sensor (G70) signal < 66 Ás

Special Notes:
In MY 1995-2002 (?) in Europe at VW-diesel-cars G70 had the bad reputation of slowly losing his performance, causing loss of power. It's not a matter of defective or breaking down, but it is filthy/dirty (not easy to clean). You can check functionality by making a log in [01-engine], [Measuring Value Blocks (MVB)-08], group 003 (3e gear, full throttle, from 1700-4000rpm).

Tech Notes:
Before replacing the mass air flow sensor, try replacing the air filter and cleaning the air flow sensor with low compress air or mass air flow sensor cleaner. Reset code and drive vehicle. If the code comes back, it may be necessary to replaced the mass air flow sensor.

When is the code detected?:
An excessively low voltage from the sensor is sent to Engine Control Module (ECM).

Description:
The Mass Air Flow (MAF) sensor is placed in the stream of intake air. It measures the intake flow rate by measuring a part of the entire intake flow. It consists of a hot film that is supplied with electric current from the Engine Control Module (ECM).

The temperature of the hot film is controlled by the Engine Control Module (ECM) a certain amount. The heat generated by the hot film is reduced as the intake air flows around it. The more air, the greater the heat loss. Therefore, the Engine Control Module (ECM) must supply more electric current to maintain the temperature of the hot film as air flow increases. The Engine Control Module (ECM) detects the air flow by means of this current change.



As taken from my https://volkswagenforum.com/forum/ge...oftware-34973/


https://volkswagenforum.com/forum/ne...gnature-34185/
 
Related Topics
Thread
Thread Starter
Forum
Replies
Last Post
kevin sherf
Volkswagen Jetta/Bora
0
07-30-2010 09:50 AM
pman4ever
Volkswagen Jetta/Bora
0
06-29-2009 03:46 PM
Lorraine2006
General Tech
2
03-30-2008 08:53 PM
Lorraine2006
Volkswagen Polo
0
03-20-2008 12:07 PM


Thread Tools
Search this Thread
Quick Reply: Solve this!


Contact Us - Archive - Advertising - Cookie Policy - Privacy Statement - Terms of Service

© 2019 MH Sub I, LLC dba Internet Brands

We are a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for us to earn fees by linking to Amazon.com and affiliated sites.